EZGO 2 Cycle Golf Cart No Spark

Discussion in 'EZGO Gas 4 Stroke' started by Billy White, May 31, 2018.

  1. Billy White

    Billy White New Member

    New coil, ignitor and voltage regulator and still no spark on my 1993 EZGO 2 Cycle golf cart. Need help
     
  2. Nubs

    Nubs Cartaholic

    Sounds like a bad or missing ground, bad connection , did you have it running before at some point?
     
  3. Billy White

    Billy White New Member

    It was running before. I have 10 or so volts at the coil. When i use a meter to read the plug voltage it is only 10 or so i think it should be more. It is a new coil and i did have it at around 30v at one time but i cant get it again and it also had a spark on the plug but only one time when u initially hit the gas.
     
  4. TColvin

    TColvin New Member

    I agree with Nubs, sound like a ground problem.
     
  5. Nubs

    Nubs Cartaholic

    So your saying that each time you hit starter it will spark once? Or you only got one spark the first time you tried it.
     
  6. Billy White

    Billy White New Member

    It had spark each time i hit the gas pedal. Now it has zero spark anytime. I have 11.5v at the coil and tried several coils qith no luck.
     
  7. Nubs

    Nubs Cartaholic

    I would check the pulsar coil, it tells the igniter to fire the coil and when. There should be a manual for that engine some where in the ezgo resources section of this forum but i’m Not so you will have to look.
     
  8. Billy White

    Billy White New Member

    I think it is the pulser coil it tested bad. I removed it and found it to be bad. Going to order one. Thanks everyone. One more guestion should the crankcase have oil in it? mine is dry or does it use sealed bearings or something
     
  9. Nubs

    Nubs Cartaholic

    Should be dry, the bearings get there lube from the oil mixed with the gas.
     
  10. Billy White

    Billy White New Member

    Well the pulser coil fixed the starting problem, it does run but misses at full throttle. To me it doesnt seem to be runing wide open when at full throttle. It does not pull very good or run fast. The compression was over 100 when i checked it.
     

Share This Page